Where is the fuel pump located on a 1996 Chevy Silverado?

Asked By: Yuzhen Boira | Last Updated: 4th May, 2020
Category: automotive road side assistance
4.7/5 (48 Views . 30 Votes)
The fuel pump on a 1996 Chevrolet truck is mounted at the top of the fuel tank, wired and routed from several connectors at its front.

Click to see full answer


Also, where is the fuel filter on a 1996 Chevy Silverado?

Remove the gas cap from the gas tank to relieve the pressure off of the fuel filter. Slide under the driver's side of the Chevrolet Silverado 1500 and locate the fuel filter. The fuel filter is located inside of the driver's-side frame rail, between the driver's-side cab of the truck and the driver's-side rear tire.

Also, what are the symptoms of a bad fuel filter? Symptoms of a Bad Fuel Filter

  • Lack of engine power. An overall lack or engine power in all gears can be due to a lack of fuel getting to the injectors.
  • Engine stalling under strain. If you find that the engine is losing power under hard acceleration or going up a steep incline, then it may be down to a bad fuel filter.
  • Random engine misfire.

Also, how do you check the fuel pump on a s10?

The only way to truly tell is to place a fuel pressure gauge on both sides of the line and get a reading from both. If your car isn't starting at all, and you hear the fuel pump prime that is usually a good indication that the pump is working to some capacity.

Where is the fuel filter on a 2000 GMC Sierra?

The fuel filter on this car is located on the driver's side, underneath the rear door, as you can see in the next image.

35 Related Question Answers Found

Where is the fuel filter?

The fuel filter is located somewhere in between your fuel tank and your engine. Typically, the fuel filter is either located inside the fuel tank (in the opening of the fuel line, which feeds gas to your car), or somewhere in the fuel line (this is usually at the bottom of your car.)

Does a 2014 Chevy Silverado have a fuel filter?

Chevy Silverado 6.6L 2014, Spin-On Fuel Diesel Filter/Water Separator by FRAM®. Spin-on. Without Drain Plug. Fuel filter is vital for any vehicle as it keeps the engine clean from contaminants.

Where is the fuel filter on a 2001 Chevy Silverado?

2001 Chevrolet Silverado 1500 - Fuel Filter/Water Separator
Your fuel filter is located between your fuel pump and fuel inlet.

Does a 2016 Chevy Silverado have a fuel filter?

Chevy Silverado 3500 HD 6.6L 2016, Spin-On Fuel Diesel Filter/Water Separator by FRAM®. Fuel filter is vital for any vehicle as it keeps the engine clean from contaminants.

How do I know if I need to change my fuel filter?


5 Signs that You Need to Replace Your Fuel Filter
  1. Car Has Difficulty Starting. This could be a sign that your filter is partially clogged and on its way to being completely dammed up.
  2. Car Won't Start. This could be caused by varying issues, and one of them is a fuel filter problem.
  3. Shaky Idling.
  4. Struggle at Low Speeds.
  5. Car Dies While Driving.

Where is the fuel filter located on a 2007 Chevy Silverado?

On gas models the filter will be under the truck running along the inside of frame rail some times above a cross member by drivers door. Diesel filter should be at the rear of intake manifold. Below are links to fuel filter locations for Chevy truck, for both diesel(link#1) or gas engine(link#2).

Where is the fuel filter on a 1998 GMC Sierra?

The fuel filter is generally located on the passenger-side frame rail, just in front of the rear tires.

Where is the fuel filter on a 2001 Chevy Silverado 2500?

The fuel filter is located on the right frame rail; you can find it by tracing the fuel lines to the canister filter. To help relieve any pressure, remove the fuel cap and be sure to have a container available to catch any fuel when removing the filter. Make sure there is no damage to the O rings prior to installation.

Where is the fuel filter on a 2005 Chevy Silverado?

"The fuel filter is located in the fuel sender assembly, inside the fuel tank. Vehicles with dual tanks, have no fuel filter in the rear tank fuel sender assembly. There is no service interval for fuel filter replacement, and no service procedure for replacing fuel filter."

Where is the fuel pump control module located?


The fuel pump control module IS NOT in the fuel tank. This component is a separate unit that monitors voltage going to the pump, and when it senses anything out of preset parameters, it illuminates the MIL in the instrument cluster. Most are located on the frame rail near the spare tire.

How do you test a fuel pump?

Hook the pressure gauge to the fuel pump test fitting.
Locate your fuel pump test point, which is usually near the fuel injectors, and locate the point at which the pump hooks up with the filter injector rail. There should be a separation joint or a test port, where the pressure gauge attaches.

How do you jump a fuel pump relay?

Insert jumper wire between Pin 30 and Pin 87 into the Fuel Pump Relay socket – you should have power at the fuel pump. Insert jumper wire between Pin 30 and Pin 87 into both relay sockets (both 87's on the main relay) - you should have power at the fuel pump AND car should start.

How hard is it to change a fuel pump?

When fuel pumps are not replaced properly, the whole system is damaged. Although it might sound difficult, fuel pump replacement is easy. Depending on the kind of fuel pump, a few set of instructions should help. Anyone can easily install a new fuel pump through these series of steps.

How much is a fuel pump for a Chevy Silverado?

The average cost for a Chevrolet Silverado 1500 fuel pump replacement is between $741 and $1,133. Labor costs are estimated between $193 and $245 while parts are priced between $548 and $888. Estimate does not include taxes and fees.

What are the signs your fuel pump is going out?


Usually, a bad or failing fuel pump will produce one or more of the following 8 symptoms that alert the driver of a potential issue.
  • Whining Noise From the Fuel Tank.
  • Difficulty Starting.
  • Engine Sputtering.
  • Stalling at High Temperatures.
  • Loss of Power Under Stress.
  • Car Surging.
  • Low Gas Mileage.
  • Car Will Not Start.

How do I know when my fuel pump is bad?

It's important to familiarize yourself with the warning signs of a faulty fuel pump—that way you can address any problems before it's too late.
  1. Engine Sputters at High Speeds.
  2. Rising Temperature.
  3. Fuel Pressure Gauge.
  4. Loss of Power When the Vehicle Is Under Stress.
  5. Surging.
  6. Decreased Gas Mileage.
  7. Engine Will Not Start.

How expensive is it to replace a fuel pump?

Taking a vehicle to a certified mechanic for repairs is the most common method for replacing a fuel pump. The average cost of replacing a fuel pump is between $400 and $600 including parts and labor. This can vary depending on the make, model and year of the vehicle.